IHS Inc. : Semiconductor Inventory Declines as Suppliers Adjust to Slow Market Conditions

Dateline:

"With the global economy all but stalled, and in the face of declining orders as well as decreased visibility, many semiconductor manufacturers opted to reduce capacity utilization. And with lead times now declining to normal levels after extended periods of waiting in the past, manufacturers were more confident about trimming..."

Chip inventories held by semiconductor suppliers declined in the third quarter of 2011, putting a halt to the steady expansion of the previous seven quarters, as the industry cut production in order to reduce oversupply,

As calculated by the days of inventory (DOI) measure, semiconductor stockpiles in the third quarter stood at 81 days, down a modest 2.5 percent from 83 days in the second quarter, according to an from information and analysis provider IHS (NYSE: IHS).

The DOI level had been on the rise since the third quarter of 2009 when it stood at just 65 days-a time when stockpiles were low because production had been reduced during the dark days of the recession.

Since then, inventory DOI had been creeping up, as shown in the figure below, partly to make up for depleted stocks, and also to cope with growing demand as strength returned to the supply chain. However, amid signs of weakening growth in the semiconductor market, the rise in inventory had generated concerns.

Global semiconductor revenue in 2011 is estimated to have risen by a scant 1.9 percent, compared to a forecast of 7 percent growth issued early in the year.

Semiconductor inventory levels are an important gauge of industry health, and the stockpile amount at any point in time also indicates the confidence-or lack thereof-of the supply chain in its forthcoming prospects. Too little inventory suggests caution for possible hard times ahead as manufacturers expect demand to ratchet down; but too much inventory is also a problem, fueling worrisome oversupply that forces down pricing.

"For the third quarter, semiconductor suppliers began an inventory correction to alleviate an escalating oversupply situation on top of already inflated stockpiles," said Sharon Stiefel, semiconductor analyst at IHS. "With the global economy all but stalled, and in the face of declining orders as well as decreased visibility, many semiconductor manufacturers opted to reduce capacity utilization. And with lead times now declining to normal levels after extended periods of waiting in the past, manufacturers were more confident about trimming bloated inventories this time around without fear of causing too much pain to the supply chain."

Despite the inventory cutback, DOI in the third quarter remained elevated in absolute terms-the highest of the last 10 quarters, dating all the way back to the fourth quarter of 2008-suggesting that stockpiles are still quite high. Moreover, the percentage of oversupply during the period rose to 12.1 percent, exceeding the 11.1 percent spike in oversupply during the fourth quarter of 2008. As a result, expectations are that inventories will be trimmed further in the fourth quarter of 2012.

Among the various semiconductor sectors, inventory levels rose for handset original equipment manufacturers, distributors and analog companies-all of which posted percentage gains in DOI. Stockpiles, however, fell for fabless semiconductor makers, memory suppliers, foundries, PC original equipment manufacturers, storage gear companies and electronic manufacturing services providers.

For mobile handset manufacturers, inventories increased in the third quarter as suppliers prepared for their seasonally busy end-of-year period. In comparison, inventory at pure-play foundries declined more strongly than expected-the result of a reduction in utilization rates.

Total DOI is estimated to have declined another 2.5 percent in the fourth quarter to 79.3 days, IHS predicts.

"Visibility continues to be murky in many sectors given the volatile world economy, and demand remains difficult to predict," Stiefel warned.

Learn more about this topic with the IHS iSuppli report entitled: "."

###

)
IHS (NYSE: IHS) is the leading source of information and insight in critical areas that shape today's business landscape, including energy and power; design and supply chain; defense, risk and security; environmental, health and safety (EHS) and sustainability; country and industry forecasting; and commodities, pricing and cost. Businesses and governments in more than 165 countries around the globe rely on the comprehensive content, expert independent analysis and flexible delivery methods of IHS to make high-impact decisions and develop strategies with speed and confidence. IHS has been in business since 1959 and became a publicly traded company on the New York Stock Exchange in 2005. Headquartered in Englewood, Colorado, USA, IHS employs more than 5,500 people in more than 30 countries around the world.

IHS is a registered trademark of IHS Inc. All other company and product names may be trademarks of their respective owners. Copyright © 2011 IHS Inc. All rights reserved.